Product ID:D-5973-E CONTINENTAL GOLD ENGINE ENAMEL
MSDS Date:04/25/1994
FSC:NIIN:Submitter:F BT
Status Code:A
MSDS Number: CKFNS

RANDOLPH PRODUCTS CO

701 12TH ST
CARLSTADT, NJ 07072-0830
US

Emergency Phone: 800-255-3924

Info Phone: 201-438-3700

Cage: 77672

RANDOLPH PRODUCTS CO

830 CARLSTADT, NJ 07072-0830 US

Telephone: 201-438-3700

Cage: 77672

ETHYLBENZENE

CAS: 100-41-4

RTECS: DA0700000

OSHA PEL 435 MG/M3;100 PPM

ACGIH TLV: 434 MG/M3;100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ALUMINUM PIGMENT

CAS: 7429-90-5

RTECS: BD0330000

OSHA PEL 15 MG/M3

ACGIH TLV: 10 MG/M3

SHORT OIL ALKYD RESIN SOLUTION

TOLUENE

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL see Table Z-2

ACGIH TLV: 188 MG/M3;50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ALIPHATIC NAPHTHA

CAS: 64742-89-8

XYLENE

CAS: 1330-20-7

RTECS: ZE2100000

ACGIH TLV: 434 MG/M3;100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:SKIN: MAY CAUSE IRRITATION & REACTS
W/SKIN PROTEIN & MOISTURE CAUSING RASH, SCALING/BLISTERING.
INHALATION: ANESTHETIC EFFECTS, CNS EFFECTS INCLUDING DEATH.
Effects of Overexposure:DRYING, CRACKING OF SKIN, IRRITATION, RASH,
SCALING, BLISTERING, HEADACHES, DIZZINESS
Medical Cond Aggravated by Exposure:PRE-EXISTING SENSITIVITY TO
SOLVENTS.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. SKIN:
FLUSH W/WATER. EYES: FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER.
INGESTION: DON'T INDUCE VOMITING. KEEP PERSON WARM, QUIET. OBTAIN
MEDICAL ATT ENTION IN ALL CASES.

Flash Point Method:SCC
Flash Point:=4.4C, 40.F
Lower Limits:0.9
Upper Limits:10
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:DON'T USE WATER HOSE STREAM. USE FULL BUNKER
GEAR IN FIRE AREA ;HELMET W/FACE SHIELD, BUNKER COAT, GLOVES,
RUBBER BOOTS. WATER MAY BE USED TO COOL CLOSED CONTAINERS TO
PREVENT PRESSURE BUILDUP, POSSIB LE AUTOIGNITION/EXPLOSION WHEN
EXPOSED TO EXTREME HEAT. REMOVE ALL NON-ESSENTIAL PERSONNEL FROM
FIRE AREA.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM IGNITION SOURCES. CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED
TO EXTREME HEAT. VAPOR IS HEAVIER THAN AIR & CAN TRAVEL
CONSIDERABLE DISTANCES TO A SOURCE OF IGNITION & FLASHBACK. WATER
STREAM WILL SPREAD FIRE.

Spill Release Procedures:AVOID BREATHING SOLVENT VAPOR. ASSURE ADEQUATE
VENTILATION. AVOID IGNITION SOURCES. ELIMINATE SOURCE OF SPILL
SAFELY W/O RISK BY CLOSING VALVE/PLUGGING HOLE. APPLY ABSORBENT
INERT MATERIAL; SAND, DUST , VERMICULITE. CLEAN W/BRISTLE BROOMS,
NON SPARKING TOOLS, CLEAN DRY RAGS. PROTECTIVE CLOTHING SHOULD BE
WORN.

Handling and Storage Precautions:DRUMS SHOULD BE GROUNDED WHEN BEING
EMPTIED.
Other Precautions:PROVIDE RESPIRATORY PROTECTION AGAINST FUMES
GENERATED DURING BURNING.

Respiratory Protection:USE NIOSH/OSHA APPROVED RESPIRATOR TYPE;
APPROVED CHEMICAL/MECHANICAL FILTERS WHEN VENTILATION IS
RESTRICTED.
Ventilation:SUFFICIENT SHOULD BE PROVIDED TO KEEP AIR CONTAMINATION
BELOW CURRENT APPLICABLE OSHA PEL/ACGHI'S TLV LIMIT.
Protective Gloves:PROTECTIVE
Eye Protection:CHEMICAL GOGGLES W/SIDE SHIELDS/FACE SHIELD
Other Protective Equipment:PROTECTIVE CREAMS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE.
Supplemental Safety and Health
USE NORMAL HYGIENE PRACTICES DURING & AFTER HANDLING THIS MATERIAL.

Boiling Pt:B.P. Text:210-295F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:THIN GOLD LIQUID W/TYPICAL SOLVENT ODOR
Percent Volatiles by Volume:60.8

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS & ALKALIES
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME & OTHER IGNITION
SOURCES
Hazardous Decomposition Products:CO, CO2

Waste Disposal Methods:SOAK LIQUIDS W/SAWDUST/RAGS & REMOVE. FLUSH
W/WATER IF POSSIBLE. AVOID SKIN CONTACT. DON'T INCINERATE, CUT/WELD
EMPTY CONTAINERS. WHEN DISCARDED THIS MATERIAL IS A HAZARDOUS
WASTE. TRANSFER LIQUID TO CONTAINERS FOR RECOVERY/DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:EPA HAZARDOUS WASTE CODE F003 HAZARDOUS WASTE
CHARACTERISTICS. IGNITABILITY.